Dependence of the Ripeness Stage on the Antioxidant and Antimicrobial Properties of Walnut (Juglans regia L.) Green Husk Extracts from Industrial By-Products.
Walnut green husk (WGH) is a waste generated by the walnut (Juglans regia L.) harvest industry. It represents a natural source of polyphenols, compounds with antioxidant and antimicrobial activities, but their activity could be dependent on the ripeness stage of the raw material. In this study, the effect of the different ripeness stages-open (OH) and closed (CH) husks-on the antioxidant and antimicrobial properties of WGH extracts were analyzed, emphasizing the influence of the extracts in inhibiting Escherichia coli growth. The ripeness stage of WGH significantly affected the antioxidant activity of the extracts. This was attributed to the different polyphenol profiles related to the mechanical stress when the husk opened compared to the closed sample. The antimicrobial activity showed inhibition of E. coli growth. OH-extracts at 96 µg/mL caused the lowest specific growth rate (µmax = 0.003 h-1) and the greatest inhibition percentage (I = 93%) compared to CH-extract (µmax = 0.01 h-1; I = 69%). The obtained results showed the potential of the walnut green husk, principally open husk, as an economical source of antioxidant and antimicrobial agents with potential use in the food industry. https://doi.org/10.3390/molecules26102878
Choline Chloride–Lactic Acid-Based NADES As an Extraction Medium in a Response Surface Methodology-Optimized Method for the Extraction of Phenolic Compounds from Hazelnut Skin.
Deep eutectic solvents (DESs) are promising green solvents for the extraction of compounds from food byproducts. Hazelnut (Corylus avellana L.) is one of the most commonly cultivated tree nuts worldwide. The skin represents one of the major byproducts of the hazelnut industry and accounts for 2.5% of the total hazelnut kernel weight. It is a rich source of phenolic compounds like flavan-3-ols, flavonols, dihydrochalcones, and phenolic acids. In this work, fifteen DESs based on choline chloride and betaine, with different compositions, were studied in order to test their phenolic compounds extraction efficiency through the determination of their total concentration via Folin-Ciocalteu assay. A qualitative analysis of extracted phenolic compounds was assessed by HPLC with UV and MS detection. Using the DES with the best extraction efficiency, a new ultrasound-assisted solid liquid extraction (UA-SLE) method was optimized though the response surface methodology (RSM), taking into account some extraction parameters. Efficient recovery of extracted phenolic compounds was achieved using a 35% water solution of choline chloride and lactic acid (molar ratio 1:2) as an extraction solvent, working at 80 °C and with a solid-to-solvent ratio of 1:25 gmL-1. The optimized conditions made it possible to recover 39% more phenolic compounds compared to a classic organic solvent. https://doi.org/10.3390/molecules26092652
Microbiomes of commercially-available pine nuts and sesame seeds
Metagenomic analysis of food is becoming more routine and can provide important information pertaining to the shelf life potential and the safety of these products. However, less information is available on the microbiomes associated with low water activity foods. Pine nuts and sesame seeds, and food products which contain these ingredients, have been associated with recalls due to contamination with bacterial foodborne pathogens. The objective of this study was to identify the microbial community of pine nuts and sesame seeds using targeted 16S rRNA sequencing technology. Ten different brands of each seed type were assessed, and core microbiomes were determined. A total of 21 and 16 unique taxa with proportional abundances >1% in at least one brand were identified in the pine nuts and sesame seeds, respectively. Members of the core pine nut microbiome included the genera Alishewanella, Aminivibrio, Mycoplasma, Streptococcus, and unassigned OTUs in the families of Desulfobacteraceae and Xanthomonadaceae. For sesame seeds, the core microbiome included Aminivibrio, Chryseolina, Okibacterium, and unassigned OTUs in the family Flavobacteriaceae. The microbiomes of these seeds revealed that these products are dominated by environmental bacterial genera commonly isolated from soil, water, and plants; bacterial genera containing species known as commensal organisms were also identified. Understanding these microbiomes can aid in the risk assessment of these products by identifying food spoilage potential and community members which may co-enrich with foodborne bacterial pathogens. https://doi.org/10.1371/journal.pone.0252605
Genotypic and Environmental Variations in Kernel Color Indices in the Main Almond (Prunus dulcis (Mill.) DA Webb) Cultivars Grown in North-Eastern Morocco.
Color indices are important quality traits that define the consumer visual acceptance and agroindustrial preferences. Little is known regarding these properties in the commercial almond cultivars grown in Morocco. This work aimed at investigating kernel color indices in five cultivars, namely, "Fournat de Brézenaud," "Tuono," "Ferragnès," "Ferraduel," and "Marcona." Color indices consisted in the following: brightness (L ∗), redness index (a ∗), yellowness index (b ∗), chroma (C ∗), hue (H ∗), and metric saturation (S ∗). Measurements were performed over three consecutive growing seasons (2016-2018) across five different sites from northern (Aknoul, Bni Hadifa, and Tahar Souk) and eastern (Rislane and Sidi Bouhria) Morocco. All factors (cultivar, growing season, and site) affected significantly studied color properties; however, genotype was the main variability source. Wide variabilities were found among cultivars. "Marcona" showed the highest L ∗, while "Ferragnès" and "Ferraduel" displayed greater scores of a ∗, b ∗, C ∗, and S ∗. Sidi Bouhria presented the lowest L ∗ but higher a ∗, H ∗, and S ∗. Moreover, Bni Hadifa displayed higher L ∗, b ∗, and C ∗. 2016 (drier growing season) had the highest values of most indices. Principal component analyses (PCA) discriminate all factors through the first three components: PC1 (61%, genetic component) and PC2 (30%) and PC3 (7%) which were of environmental nature since they separate sites and growing seasons, respectively. Despite environmental effects, we suggested a possible discrimination among the studied cultivars based on their kernel color indices. Drought conditions during fruit development seemed to improve kernel quality via synthesis of pigments resulting in higher a ∗ and b ∗. https://doi.org/10.1155/2021/9970223
Analysis and quantification of naturally occurring aflatoxin B1 in dry fruits with subsequent physical and biological detoxification.
Current research involves extraction, identification and detoxification of mycotoxins from ten dry fruit samples. Mycotoxins were identified by high performance thin layer chromatography followed by physical and biological detoxification, analysed by HPLC. Three fungal species were observed after isolation including, Aspergillus niger, Aspergillus flavus and Fussarium sp. HP-TLC analysis revealed the presence of mycotoxin, aflatoxin B1 ranging from 0.000303-0.03636 mg/kg in all samples. Results were further analysed through various statistical tests. Detoxification methods proved to be cost effective and easily implementable. Concentration of aflatoxin B1 in pine nuts was reduced to 0.0043 mg/kg and 0.0039 mg/kg in dry dates through UV based detoxification. Solarisation reduced the concentration of aflatoxin B1 in figs to 0.0044 mg/kg. 90% aflatoxins were detoxified by UV treatment while Zingiber officinale powder detoxified 90% mycotoxin. This research concludes that the studied detoxification methods can be generalised on larger scale to benefit the dry fruit industry worldwide. https://doi.org/10.1080/14786419.2021.1935930
Sensitive Metal Oxide-Clay Nanocomposite Colorimetric Sensor Development for Aflatoxin Detection in Foods: Corn and Almond.
The work reports on zinc oxide bentonite nanocomposite (ZnOBt) chemical route synthesis, characterization, and investigation of curcumin (Cur) functionalization for a label-free colorimetric detection of total aflatoxins (AFs) in foods. XRD of ZnO nanoparticles (NPs) confirmed the wurtzite structure (2θ = 36.2°) and that of ZnOBt showed the intercalated interlayer composite phase. The Debye-Scherrer relation calculated the crystallite size as 20 nm (ZnO) and 24.4 nm (ZnOBt). Surface morphology by SEM exhibited flower-like hexagonal, rod-shaped ZnO NPs on the bentonite surface. Colorimetric reaction involved two-stage redox reactions between ZnOBt and dye Cur followed by AFs phenolic group and Zn(Cur)OBt. Cur gets oxidized at its diketone moiety in the presence of ZnOBt to form a red colored complex Zn(Cur)OBt, which further scavenge protons from AFs phenolic group, and gets oxidized to AFs-Zn(Cur)OBt (yellow). Binding of AFs-Zn(Cur)OBt is characterized by FT-IR ascribed to C-H bending (1966.615 cm-1), O-H stretching (3256.974 cm-1), and C=O stretching (1647.362 cm-1). 1H NMR chemical shifts (δ) (ppm) showed an increase in proton at the aliphatic region (0 to 4.4) while removal of proton in ether at 4.4 to 6 regions. Job plot calculation using UV-Vis data resulted in a higher total AF binding coefficient of Zn(Cur)OBt (K a = 3.77 × 106 mol-1 L) compared to Zn(Cur)O (K a = 0.645 × 106 mol-1 L) as well as a molar ratio of 1:1 by the Benesi-Hildebrand plot equation. Corn and almond food samples showed the total AFs LOD of 2.74 and 4.34 ppb, respectively. The results are validated with standard LC/MS-MS in compliance with MRL value as per the regulatory standard (EU).The NP-based method is facile and rapid and hence can be utilized for onsite detection of total AFs in foods. https://doi.org/10.1021/acsomega.1c00750
Chemometric Approach Based on Accuracy Profile and Data Chronological Distribution as a Tool to Detect Performance Degradation and Improve the Analytical Quality Control for Aflatoxins’ Analysis in Almonds Using UPLC–MS/MS.
One of the main objectives of routine laboratories is the development of simple and reliable methods as well as meeting fit-for-purpose criteria for regulatory surveillance. In this study, the accuracy profiles and the evaluation of the distribution of results in the case of aflatoxins in almonds have been performed using ultraperformance liquid chromatography-tandem mass spectrometry (UPLC-MS/MS). The method consists of designing the experiment and using certified reference material (CRM) to evaluate the bias, to calculate the combined uncertainty, and to construct the control charts. Good sensitivity (limit of quantifications (LOQs) 0.34-0.5 μg/kg) and recovery (between 82 and 107%) were achieved. The proposed method was successfully tested with a proficiency test in almond powder with acceptable z scores (-2 ≤ z ≤ 2). The results provided direct evidence for the proper functioning and stability of the whole analytical protocol, allowing acceptable combined uncertainty. https://doi.org/10.1021/acsomega.1c01056
Estimation of Tolerable Daily Intake (TDI) for Immunological Effects of Aflatoxin.
Aflatoxins are toxic chemicals produced by the fungi Aspergillus flavus and Aspergillus parasiticus. In warm climates, these fungi frequently contaminate crops such as maize, peanuts, tree nuts, and sunflower seeds. In many tropical and subtropical regions of the world, populations are coexposed to dietary aflatoxin and multiple infectious pathogens in food, water, and the environment. There is increasing evidence that aflatoxin compromises the immune system, which could increase infectious disease risk in vulnerable populations. Our aim was to conduct a dose-response assessment on a noncarcinogenic endpoint of aflatoxin: immunotoxicological effects. We sought to determine a noncarcinogenic tolerable daily intake (TDI) of aflatoxin, based on the existing data surrounding aflatoxin and biomarkers of immune suppression. To conduct the dose response assessment, mammalian studies were assessed for appropriateness of doses (relevant to potential human exposures) as well as goodness of data, and two appropriate mouse studies that examined decreases in leukocyte counts were selected to generate dose response curves. From these, we determined benchmark dose lower confidence limits (BMDL) as points of departure to estimate a range of TDIs for aflatoxin-related immune impairment: 0.017-0.082 μg/kg bw/day. As aflatoxin is a genotoxic carcinogen, and regulations concerning its presence in food have largely focused on its carcinogenic effects, international risk assessment bodies such as the Joint Expert Committee on Food Additives (JECFA) have never established a TDI for aflatoxin. Our work highlights the importance of the noncarcinogenic effects of aflatoxin that may have broader public health impacts, to inform regulatory standard-setting. https://doi.org/10.1111/risa.13770
Effect of Tractor Speed and Spray Application Volume on Severity of Scab at Different Heights in the Canopy of Tall Pecan Trees.
Scab (caused by Venturia effusa) is the most important yield-limiting disease of pecan in the southeastern USA. On susceptible cultivars, the disease is managed using fungicides, but spray coverage is an issue in tall trees. In four experiments we used an air-blast sprayer to compare scab severity on fruit at 5.0 to 15.0 m height in trees receiving the same dose of fungicide at 468, 935 and 1871 L/ha at 2.4 and 3.2 km/h (in two additional experiments fungicides were applied at 4.0 km/h @ 470 L/Ha, 4.0 km/h @ 940 L/Ha and 4.0 km/h @ 1100 L/Ha). An air-blast sprayer was used for the applications, which included typical recommended active ingredients (a.i.). Nozzles were selected to provide similar proportions of spray to the upper and lower canopy. The treatments (or subsets thereof) were repeated in 2015 to 2017 on cv. Schley, and in 2017, 2019 and 2020 on cv. Desirable. All treatments reduced scab compared to the control. Overall, there was no consistent difference among the treatments for severity of scab on foliage, immature fruit, or mature fruit at any height in the canopy up to 15.0 m (maximum height sampled). Fungicide applied at 2.4 or 3.2 km/h @ 470 L/ha was as effective at reducing disease as were the higher volumes (sometimes more so). The scab epidemic severity affected control efficacy. Estimated cost and water savings based on faster speed and lower volume were considerable. These preliminary observations indicate no single volume or speed was consistently superior to control scab; this suggests in most seasons, low volumes (higher concentration of a.i.) may be similarly efficacious as high volumes (lower concentration of a.i.) for controlling scab in tall pecan trees, and offer greater resource use efficiency. https://doi.org/10.1094/PDIS-03-21-0526-RE
Comparative Study of Chemical Compositions and Antioxidant Capacities of Oils Obtained from 15 Macadamia (Macadamia integrifolia) Cultivars in China.
The planting area of macadamia in China accounted for more than one third of the world's planted area. The lipid compositions, minor components, and antioxidant capacities of fifteen varieties of macadamia oil (MO) in China were comparatively investigated. All varieties of MO were rich in monounsaturated fatty acids, mainly including oleic acid (61.74-66.47%) and palmitoleic acid (13.22-17.63%). The main triacylglycerols of MO were first time reported, including 19.2-26.1% of triolein, 16.4-18.2% of 1-palmitoyl-2,3-dioleoyl-glycerol, and 11.9-13.7% of 1-palmitoleoyl-2-oleoyl-3-stearoyl-glycerol, etc. The polyphenol, α-tocotrienol and squalene content varied among the cultivars, while Fuji (791) contained the highest polyphenols and squalene content. Multiple linear regression analysis indicated the polyphenols and squalene content positively correlated with the antioxidant capacity. This study can provide a crucial directive for the breeding of macadamia and offer an insight into industrial application of MO in China. https://doi.org/10.3390/foods10051031